SV650 compression?

Started by sv303, September 24, 2006, 10:24:32 PM

0 Members and 1 Guest are viewing this topic.

sv303

Has anyone taken a compression reading of a stock sv650? (1999-2002) In the manual it states that the standard compression reading should be around 213 psi, the lower limit is 156 psi, and the difference between the two cyclinders can be 28psi.  My rear cyclinder is 195psi and my front is 230psi.  I'm not sure if this is a problem or not.   I'm just trying to find out what others have?

Thanks

Kevin
#303

SV88

I'd say it's a bit of a problem... Mine (00 with 34k miles) are both around 200 psi.  Where do you get the specifications?  I think our motors are roughly 10.5:1 which translates to 175 psi (14.7 psi per atmosphere).  YOu probably have some carbon build-up in the rear cylinder which tends to run a little richer ... I suspect that's your high compression cyclinder.

Steve.
Fastsv650/SVR6/Steve sv23
09R6rdrace,13KTM250xc enduro,03SV1000N, 99-02 sv650 project
ret. CCS MW/FL/SE 88  Moto A SSP 881

AZ-MilleR

I remember being aorund 195 / cylinder when I tested my 2001 SV last year, and both cylinders were very close.
Alan
CCS AM #613 - Southwest
'01 Suzuki SV650
2005 SW AM Thunderbike Champion
2005 SW AM LW Supersport Champion

grasshopper


sv303

I just did a leak down test,  both cylinders are right around 10 %.  The front cylinder is the one with high compression. 

Super Dave

Been a while since I've been around lead down numbers, but 10% seems to be a lot.
Super Dave

Protein Filled

230 is really high for a stock motor. Is there any work that has been done to the bike? If you really have 230 Lbs of Cold Cranking Compression you need to run high octane fuel since you may get some detonation. If the motor is 100% stock, I would double check carbon buildup as well as cam timing. Sounds to me like it's time to freshen her up. I had one SV that was up to 250 lbs and we toned it down since it would be too easy to grenade something at that rate.
Edgar Dorn #81 - Numbskullz Racing, Mason Racin Tires, Michelin, Lithium Motorsports



Don't give up on your dreams! If an illiterate like K3 can write a book, imagine what you can do!